中科攪拌機分享如何讓混凝土攪拌機延長使用時間？
有些用戶會見到有些操作混凝土攪拌機的工作人員會在混凝土攪拌機傳動齒輪每天開機前應涂抹黃油少許.并在鏈條上加涂少量的潤滑脂,每工作300小時清洗鏈條一次,每星期打開一次各傳動鏈條罩殼?；炷翑嚢铏C每班工作結束后將混合料存?zhèn)}中的物料排放干凈,切斷總電源,檢查攪拌臂與葉漿的緊固情況,發現螺母松動應立即擰緊，這些都是日常所需要注意的。混凝土攪拌機的使用壽命與日常保養有相當大的關系，中科攪拌機提醒您混凝土攪拌機維修和保養應注意以下幾點：
Some users will see that some workers who operate the concrete mixer will apply a little butter before starting the concrete mixer drive gear every day, and apply a small amount of grease on the chain, clean the chain once every 300 hours, and open the cover of each drive chain once a week. After the end of each shift of the concrete mixer, the materials in the storage bin of the mixture shall be discharged, the main power supply shall be cut off, and the fastening condition between the mixing arm and the blade slurry shall be checked. If the nut is loose, it shall be tightened immediately. These are the daily needs. The service life of concrete mixer is closely related to daily maintenance. Zhongke mixer reminds you of the following points in the maintenance and repair of concrete mixer:
（1）各部分緊固螺栓經常檢查，特別是攪拌機座、電機座、葉片與襯板，以防松脫。
(1) Check the fastening bolts of all parts, especially the mixer base, motor base, blade and lining plate, to prevent loosening.
?。?）更換混凝土攪拌機葉片時應用標準扭力扳手，鎖緊力矩應達200-220N．ｍ。
(2) When replacing the blade of concrete mixer, the standard torque wrench should be used, and the locking torque should be 200-220n. M.
?。?）混凝土攪拌機攪拌葉片與襯板之間磨損間隙過大時，筒體水平兩側應調≤5mm。
(3) When the wear clearance between the mixing blade and the lining plate of the concrete mixer is too large, the horizontal sides of the cylinder should be adjusted to ≤ 5mm.
?。?）減速機潤滑油要按標準定期更換。
(4) The lubricating oil of reducer shall be changed regularly according to the standard.
?。?）檢查混凝土攪拌機潤滑泵是否按程序設置正常工作。
(5) Check whether the lubrication pump of concrete mixer works normally according to the program setting.
?。?）每班次或停機前要清洗攪拌桶、軸、葉片。
(6) Clean the mixing drum, shaft and blade before each shift or shutdown.
（7）同步齒輪、傳動鏈條要定期清理，加潤滑油脂。
(7) The synchronous gear and transmission chain should be cleaned regularly and lubricated.
?。?）冰凍季節，應將噴水系統內存水放凈。
(8) In the freezing season, the water in the sprinkler system should be drained.
以上是關于如何延長混凝土攪拌機使用時間的相關內容介紹，希望對大家有所幫助，如您想要購買混凝土攪拌機，歡迎來中科攪拌機官網http://www.pheenet.cn選購，中科攪拌機優惠，是您的不二之選！
The above is about how to prolong the use time of concrete mixer, hope to help you, if you want to buy concrete mixer, welcome to the official website of Zhongke mixer http://www.pheenet.cn Purchase, Zhongke mixer price concessions, is your only choice!
